Biological desulfurization of biogas (biogas desulfurization for short) is a process for removing corrosive and toxic hydrogen sulfide gas from biogas by using biological bacteria. This process has the advantages of high automation, simple process and low operation cost. The following biogas biological desulfurization small edition will give you a detailed introduction to the principle of this process, I hope to help you!
The biogas produced by anaerobic fermentation enters the scrubbing tower and is absorbed by alkaline circulating spray to remove hydrogen sulfide in biogas. The rich liquid absorbed hydrogen sulfide is refluxed into the bioreactor, and the hydrogen sulfide is converted into solid sulfur by bioconversion, and the solution is regenerated into alkaline absorbent (also as lean liquid) which can be used to wash biogas, thus realizing the recovery and recycling of absorbent. Separation of sulfur solids is realized by sulfur precipitator.
This process combines the physical and chemical absorption of hydrogen sulfide under weak alkaline condition with the biological regeneration of alkaline solution under the action of air. The biogas containing hydrogen sulfide enters the scrubbing tower, where it is washed by alkali solution absorbed hydrogen sulfide. The removal rate of hydrogen sulfide from the treated biogas is as high as 99.5%. After the system treatment, biogas can be used for gas generator power generation, as boiler fuel or input to local small gas supply network.
Biogas with little hydrogen sulfide escaped from the top of the scrubber and hydrogen sulfide solution flowed into the bioreactor, where the bacteria oxidized it to sulfur and alkali under limited oxygen supply. A small amount of effluent (sodium salt) and by-product sulphur of the system do not contain sulphide, and there is no problem in discharge.
This is the end of today's introduction. I believe that the above introduction can bring you some help. If you still don't understand the content of this article, you are welcome to leave a message on the official website of biogas desulfurization for discussion: http://www.jfshop.net/old.